Product ID:CARBON DIOXIDE,322
MSDS Date:08/15/1996
FSC:4210
NIIN:01-361-6921
MSDS Number: CFKKM

Emergency Phone: 205-655-3271/800-424-9300(CHEMTREC)

Info Phone: 205-655-3271

Cage: 54905

Telephone: 205-655-3271

Cage: 54905

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 100%

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;96

LD50 LC50 Mixture:TLV IS 5000 PPM.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:LUNGS, CNS, EYES, SKIN.
ACUTE- CONTACT WITH LIQUID CAN CAUSE SKIN FROSTBITE. GAS MAY CAUSE
EYE IRRITATION. ASPHYXIANT. INHALATION MAY CAUSE RESPIRATORY
ACIDOSIS. HIGH CONCENTRATIONS MAY CAUSE RAPID CIRCULATORY
INSUFFICIENCY LEADING TO DEATH. INGESTION IS NOT LIKLEY (GAS).
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE OR SKIN FROSTBITE AND FREEZE BURNS,
HEADACHE, DROWSINESS, DIZZINESS, STINGING OF THE EYES, NOSE AND
THROAT, EXCITATION, RAPID BREATHING AND HEART RATE, EXCESS
SALIVATION, SHORTNESS OF BREATH, MUSC ULAR WEAKNESS, RINGING IN THE
EAR, UNCONSCIOUSNESS, COMA, NAUSEA, VOMITING, WATERY EYES
(FORMATION OF WEAK CABONIC ACID)
Medical Cond Aggravated by Exposure:PERSONNEL WITH PRE-EXISTING CHRONIC
RESPIRATORY DISEASES OR HEART DISORDERS SHOULD REFRAIN FROM
BREATHING EXCESSIVE CARBON DIOXIDE.

First Aid:INHALATION:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
EYES:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SEE AN
OPHTHALMOLOGIST, URGENTLY. SKIN:FLUSH WITH WARM WATER (NOT TO
EXCEED 107 F). PROMPT MEDICAL ATTENTION IS MANDATORY IN ALL CASES
OF OVEREXPOSURE TO CARBON DIOXIDE. RESCUE PERSONNEL SHOULD BE
EQUIPPED WITH SELF CONTAINED BREATHING APPARATUS. ORAL:NOT LIKELY.

Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:CARBON DIOXIDE CANNOT CATCH FIRE. USE WATER FOG,
CARBON DIOXIDE, FOAM, OR DRY CHEMICAL FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY. EVACUATE AREA.
Unusual Fire/Explosion Hazard:CYLINDERS MAY RUPTURE.

Spill Release Procedures:LIQUID CARBON DIOXIDE WILL FORM SOLID CO2 (DRY
ICE) WHEN RELEASED TO ATMOSPHERIC PRESSURE. THE AREA SHOULD BE
VENTILATED. CLEAN UP PERSONNEL SHOULD WEAR SELF-CONTAINED BREATHING
APPARATUS WITH FULL FA CE MASK AND HEAVY PROTECTIVE CLOTHING.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A COOL, WELL-VENTILATED
PLACE. DO NOT STORE ABOVE 120F. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:KEEP AWAY FROM SOURCES OF HEAT. CAUTION! CAN CAUSE
RAPID SUFFOCATION DUE TO OXYGEN DEFICIENCY. USE WITH ADEQUATE
VENTILATION. CO2 IS HEAVIER THAN AIR AND TENDS TO ACCUMULATE NEAR
THE FLOOR IN CLOSED S PACES. READ ALL LABELS INSTRUCTIONS.

Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. HOWEVER,
AIR-SUPPLIED RESPIRATORS ARE REQUIRED WHILE WORKING IN CONFINED
SPACES WITH THIS PRODUCT. THE RESPIRATORY PROTECTION USE MUST
CONFORM WITH OSHA RULES AS SPECIF IED IN 29 CFR 1910.134.
Ventilation:SUFFICIENT TO PREVENT ACCUMULATION ABOVE TLV. LOCAL EXHAUST
LOCATED NEAR THE FLOOR.
Protective Gloves:RUBBER
Eye Protection:SAFETY GOGGLES
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER,
INDUSTRIAL-TYPE WORK CLOTHING, SAFETY SHOES AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health

HCC:G3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:SUBLIMES
Vapor Density:1.52
Spec Gravity:1.3
pH:ACIDIC
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT (GAS)
Solubility in Water:SOLUBLE
Appearance and Odor:COLORLESS, ODORLESS COMPRESSED GAS
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
WATER, CHEMICALLY ACTIVE METALS SUCH AS SODIUM, POTASSIUM, TITANIUM
Stability Condition to Avoid:OVERHEATING CYLINDERS
Hazardous Decomposition Products:NONE

Waste Disposal Methods:SLOWLY RELEASE INTO ATMOSPHERE OUTDOORS.
DISPOSAL SHOULD BE IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS. DEFECTIVE CYLINDERS SHOULD BE TAGGED TO INDICATE A
DEFECT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.